Golf cart batteries are one of the most versatile batteries readily available for either a small home, cabin or for someone just starting to live off the grid. Some may think that this lowly battery has no place in the real world of energy storage, but it is applicable in some situations and can be relatively cost effective.
This battery is typically referred to as “golf car” or “golf cart” battery. We are not golfers so therefore do not know the intricacies that make the distinction between a cart or car so we will stick with “golf cart” from here on.
At first glance it looks like something you might pull out of an automobile or truck that is used for engine starting. The difference being it only has three cells as opposed to six in a starting battery. There is an 8 volt golf car battery but the vast majority are the 6 volt type. While an 8 volt battery may be an advantage in a vehicle to reduce weight, for renewable energy storage the 6 volt will be more cost effective.
Most likely if you have had any exposure to renewable energy storage, you already know that a car starting battery is an extremely poor choice for socking away those ampere hours for later use. But, if you have been hanging around the battery section at the department store, you may have also seen something that looks like a car battery, it’s 12 volt, contains “deep cycle” in the description and sells for a reasonable price. You go home thinking that you have found the secret to the high cost of storage batteries. Before you decide to go back and load up your truck with this cheap solution, let’s look at the drawbacks.
Why use Golf Cart batteries over a Marine Deep cycle or Auto battery?
We all know that the lead acid batteries are chemical storage containers and can exhibit different characteristic depending on how they are constructed. With the 12 volt car starting battery, there are twice as many thin plates in comparison to the 6 volt golf cart batteries. The starting battery has much more plate exposure resulting in it being able to give up a lot of electrons in short bursts. On the other side, heavy charge-discharge cycles for prolonged periods of time can distort and damage the thin, delicate plates. Furthermore, the positive plates will corrode much faster than a true deep cycle battery – which results in a very short lifespan.
6 volt golf cart batteries, with its thicker plates, are able to endure long periods of deep discharging and recharging with less effect on its life span.
A product that can be tempting for a first-time battery buyer is the Group 24 or 27 RV or Marine deep cycle battery. These can be found at auto parts stores, department stores and discount warehouses. This particular battery comes up in discussions often enough to know that people are taking serious look at one of these for their house system. They are 12 volt batteries and it doesn’t matter what “new” technology they advertise, they are still a cross between a starting and deep cycle design.
Power Point
If there is a reference to Cold Cranking Amps (CCA), it is most likely one of these dual purpose batteries and should be avoided.
To explain it in cost effective detail, let’s look at how many ampere hours (AH) you can draw out of a Group 27, 12 volt dual purpose battery, versus a typical GC-2 golf cart 6 volt battery. As an example we will use a comparison of the West Marine brand to avoid mixing different brands and pricing structures.
The Group 27 battery cost $120, has an advertised discharge life cycle of 200 and is rated at an AH capacity of 80. The GC-2 costs $190, life cycle of 700 and is rated at an AH capacity of 215. We will use 2 Group 27 batteries connected in parallel to maintain 12 volts and provide a 160 AH capacity. Two GC-2’s will be hooked in series to provide 12 volts and a 215 AH capacity.
Battery Type | Amp Hour Capacity | Cycle Life | Total Battery Cost | Total AH’s provided at 80% DOD* | Lifetime Cost per 100 AH’s |
| Group 27 | 160 | 200 | $240 | 25,600 | $0.94 |
| GC-2 | 215 | 700 | $380 | 120,400 | $0.32 |
According to the spec’s provided, the more expensive GC-2’s will actually cost a third that of the cheaper Group 27. As far as comparing various brands, the plate thickness will be one of the top determining factors that you can use as a general guide. The only problem you will encounter is this number is not typically published in the spec’s for the GC-2 type of battery.
Something else that will complicate matters is the variation in manufacturers with various “store brands”. For example Costco, Sams Club and Walmart may carry the GC-2 but it will most likely have a store label instead of the company that actually made it. To compound this problem, the contracts for these batteries can vary from state to state and from time to time according to who has the lowest bid. This will mean that the Sams Club golf cart batteries your buddy purchased 3 years ago and is still going strong, may not be the same battery today. If you think golf cart batteries are right for you, several inquires might land you more specific and helpful information.
The problem that makes it hard to turn down the Warehouse Club golf cart battery is the price. We have found them to be the cheapest, by far, than any other source.
Our Experience with Golf Cart Batteries
The third set of batteries to store power for the Ranch was a set of Sams Club GC-2’s. We had two sets of eight hooked in series and then each bank was connected to a buss bar for a 420 AH capacity. These lasted 12 months. Thinking that maybe we just got a bad batch, we tried the same thing again. Twelve months later we were again looking at 16 depleted little batteries.
We kept them charged, watered and clean and didn’t abuse them with microwaves and such. The largest DOD they were subjected to was 35% with the average more like 20% – 25%. Even if you considered each day for a year as a “cycle” that would be only be 365 which is short of the average 500 which we see on a lot of charts. If we had been hammering them daily with high load devices, this might be understandable but the typical draw we have is in the 3 – 10 ampere range. One thought was that we should have added another bank of 8 the second time around, for a total of 24 to ease the average load per battery.
Conclusion
Golf Cart batteries certainly have their place. For the price, we would not hesitate to use them for a small load application or where larger batteries are not feasible such as in remote locations. Keep in mind that to our short lived experience, there are many others who have had multiple years on a set with no problems. If you are planning to use a store brand, searching out the specs such as plate thickness would be advisable so you can do a little comparison shopping
Golf Cart batteries certainly have their place. For the price, we would not hesitate to use them for a small load application or where larger batteries are not feasible such as in remote locations. Keep in mind that to our short lived experience, there are many others who have had multiple years on a set with no problems. If you are planning to use a store brand, searching out the specs such as plate thickness would be advisable so you can do a little comparison shopping.
What Other Visitors Have Said
Click below to see contributions from other visitors to this page…
GC-2 golf cart Batteries are good, but Not all golf cart batteries are the same Interstate made in Mexico??? 
I have a solar system; about five years ago, I bought a set of batteries. First I tried the marine deep cycle but they only last a year or so. At the same …
Golf Cart Batteries in my camper
I have had Golf Cart Batteries in my camper that I have lived in for 16 years. I tend to get 7 years of life or so from my 4 batteries. At one point …
Your problem is that you used cheapo golf cart batteries. 
You should have paid just a tad extra and picked up some U.S. Battery, Trojan, or Crown. Even an interstate 232AH battery which, is from what I can tell, …
Life off the Grid Not rated yet
We have lived off the grid for 20+ years. Our experience with golf cart batteries, 12 of them, hooked up for a 24V system has been excellent. They have …
GC2 Battery Mismatched application Not rated yet
My opinion only ………. but ……….. After reading your experience above, I would like to share my perspective for what it may be worth. I …
GC2’s lasted 5 years and maybe could do more Not rated yet
September of 2010 I bought 6 GC2’s from Costco for our cabin and I promptly began abusing them. A year later having killed the bank twice (oops left the …
Thank you very much for the info on GC’s. Not rated yet
My darling and I have drawn back from our 5th wheel to an amazingly simple 1996 Okanagan camper van. We took out 2 1/2 pickup loads from our fifth wheel …
Cosco 6 v gold cart batteries Not rated yet
I’m a newbie in solar. Off-grid and need a small amount of power for the well pump, laptop and a few led lights. Bought 800 watts of panels – they work …
How to maintain golf cart batteries for longevity Not rated yet
Look at how a golf cart battery are use in a golf cart. Run down by day and recharged at night,a hard life. In most off grid systems they have low …
Costco golf cart batteries Not rated yet
I use 12 6V Costco golf cart batteries to power my off-grid permanent residence. They are connected to a single charge controller and two 2400W stacked …
12 volt Trojan Golf Cart Batteries & Battery Saver Not rated yet
I have been running golf cart batteries in my golf cart for 10 years. This is several different carts. My education on batteries is that they go bad because …
Sams Club golf cart batteries Not rated yet
I have a small heavy metal cart with 2 sets of golf cart batteries in series with an 1600 inverter and a battery charger, mainly for power failure. Because …
to golf cart or not to golf cart Not rated yet
We have used golf cart batteries for over 12 years (different sets of course) on our 45 foot sailboat, 4 of which were spent living aboard in warm climates. …
Solar house Not rated yet
I have a solar house in the Caribbean. It uses 16 of Trojan T105 cycling up to 50% daily. After 6 years, 15 are still usable but probably with capacity …